农业机械学报2017，Vol.48Issue(4)：41-46,6.DOI:10.6041/j.issn.1000-1298.2017.04.005
基于PWM变量喷雾的单喷头动态雾量分布均匀性实验
Experiment on Dynamic Spray Deposition Uniformity for PWM Variable Spray of Single Nozzle
摘要
Abstract
The spray deposition uniformity is an important measure index to evaluate spray quality.Through improving the spray deposition uniformity,the pesticides can be saved under the premise of high pesticide effect.Aiming at studying the uniformity characteristics of dynamic spray deposition for PWM variable spray system,the carmine solution was used as spray reagent and matrix tray with holes was put on the conveyor to collect droplets,and then the spray deposition concentrations of each hole were calculated by the method of concentration-absorbance measurement.The impacts of spray pressure,frequency and duty cycle of PWM signal on spray deposition uniformity for single nozzle were tested from three aspects of whole area,forward moving and spray bar direction.The research results suggested that for single nozzle,the frequency of PWM signal had bigger impact on spray deposition uniformity in forward moving direction than that in spray bar direction and there was no need to set too large value of frequency unless it was required to guarantee the continuity of spray.Moreover,before the duty cycle of PWM signal reached a certain value that the flow rate of spray became stable,the duty cycle only influenced the spray deposition uniformity in forward moving direction significantly for single nozzle,and when the duty cycle was bigger than the value,it can influence the spray deposition uniformity in both the forward moving and spray bar directions for single nozzle.The results also indicated that the spray pressure had opposite effect on spray deposition uniformity in forward moving and spray bar directions for single nozzle.These results could provide references for setting operating parameters of spray work and studying the uniformity characteristics of dynamic spray deposition for multi nozzles.关键词
植保机械/变量喷雾/脉宽调制/雾量分布均匀性Key words
plant protection machinery/variable spray/pulse width modulation/spray deposition uniformity分类
农业科技引用本文复制引用
蒋焕煜,张利君,刘光远,施玮囡..基于PWM变量喷雾的单喷头动态雾量分布均匀性实验[J].农业机械学报,2017,48(4):41-46,6.基金项目
国家高技术研究发展计划(863计划)项目(2012AA10A504)、农业部引进国际先进农业科学技术项目(2011-G32)和浙江省“新世纪151人才工程”项目 （863计划）
