首页|期刊导航|中国资源综合利用|氯化液的锌回收试验研究

氯化液的锌回收试验研究OACHSSCD

Experimental Study on Zinc Recovery from Chloride Solution

中文摘要英文摘要

本文采用石灰乳中和沉淀法从氯化液中回收锌,获得较好的效果.试验结果表明,在Ca(OH)2 乳液浓度 20%、搅拌时间 3 h,终点pH=10 的条件下,小型试验中锌渣的锌、铅含量分别为 58.24%、9.18%,沉锌率、沉铅率分别为 93.23%、94.15%;中间试验中锌渣的锌、铅含量分别为 58.76%、9.26%,沉锌率、沉铅率分别为 93.15%、94.18%.结果显示,锌、铅回收率分别超过 93%、94%,且指标重复性好,为下一步应用于工业实践提供数据支撑.

This paper uses lime milk neutralization precipitation method to recover zinc from chloride solution,achieving good results.The experiment results show that under the condition of 20%Ca(OH)2 lotion concentration,3 h stirring time and pH=10 at the end point,the zinc and lead contents of zinc slag in the small test are 58.24%and 9.18%respectively,and the zinc and lead deposition rates are 93.23%and 94.15%respectively;in the intermediate experiment,the zinc and lead contents of zinc slag are 58.76%and 9.26%,respectively,and the zinc and lead deposition rates are 93.15%and 94.18%,respectively.The results show that the recovery rates of zinc and lead exceed 93%and 94%respectively,and the indicators have good repeatability,providing data support for the next step of application in industrial practice.

胡磊;梁新星;郭持皓;梁东东;孙贯永

矿冶科技集团有限公司,北京 100160北方矿业有限责任公司,北京 100053矿冶科技集团有限公司,北京 100160矿冶科技集团有限公司,北京 100160矿冶科技集团有限公司,北京 100160

冶金工业

石灰乳中和沉淀法氯化液

lime milkneutralization precipitation methodchloride solutionzinclead

《中国资源综合利用》 2023 (12)

8-12,5

矿冶科技集团基金资助项目(YJT2017012).

10.3969/j.issn.1008-9500.2023.12.003

评论