农业机械学报2024，Vol.55Issue(5)：135-147,166,14.DOI:10.6041/j.issn.1000-1298.2024.05.012
玉米籽粒收获机组合筛面预筛分式清选装置设计与试验
Design and Experiment of Pre-screening Cleaning Device for Combined Screen Surface of Corn Grain Harvester
摘要
Abstract
In view of the fact that the current corn grain harvester can not meet the need of large feeding quantity cleaning above 15 kg/s,a kind of cleaning device with pre-cleaning function was designed.Firstly,the stress analysis of corn grains before the extruder leaved the screw conveyor and reached the pre-cleaning screen was carried out,and then the motion model of the crank linkage mechanism was simplified.Secondly,the motion state of corn grains on the sieve surface was analyzed.The impeller and volute of centrifugal fan were designed and calculated.The single factor test was used to determine the fan speed,vibration frequency and the value range of the upper screen opening.With the fan speed,vibration frequency and the opening of the upper screen as test factors,and the grain impurity content and cleaning loss rate as evaluation indexes,the three-factor and three-horizontal center combined test was designed to establish a regression model between the factors and indexes.The test results were analyzed by response surface method,and the regression model was optimized by Design-Expert 12.When the feeding amount of corn extract was 16 kg/s,the optimal combination was obtained.The test results showed that the fan speed was 1 202.50 r/min,the vibration frequency was 5.41 Hz,and the opening of the upper screen was 18 mm.Under these conditions,the grain impurity content was 0.79％and the cleaning loss rate was 1.10％.The verification test showed that the speed of the fan was 1 200 r/min,the vibration frequency was 5 Hz,and the opening of the upper screen was 18 mm.At this time,the kernel impurity content was 0.82％,the cleaning loss rate was 1.14％,the relative error between the test value and the optimization value was less than 5％,and the kernel impurity content was 2.07 percentage points lower than that of the traditional double-layer reciprocating vibrating screen cleaning device.The loss rate of cleaning was reduced by 2.13 percentage points,which proved that the design was reasonable and met the national cleaning standard.关键词
玉米籽粒收获机/预清选装置/大喂入量/曲柄连杆机构Key words
corn grain harvester/pre-cleaning device/large feeding quantity/crank linkage mechanism分类
农业工程引用本文复制引用
王飞,阿力木·买买提吐尔逊,张俊三,李谦绪,徐路明..玉米籽粒收获机组合筛面预筛分式清选装置设计与试验[J].农业机械学报,2024,55(5):135-147,166,14.基金项目
新疆维吾尔自治区重点研发计划项目(2022B02016) （2022B02016）
