清华大学学报（自然科学版）2026，Vol.66Issue(3)：440-451,12.DOI:10.16511/j.cnki.qhdxxb.2026.26.011
大型液氢库区泄漏扩散全尺度模拟及安全分析
Full-scale simulation and safety analysis of leakage and dispersion in large-scale liquid hydrogen storage areas
摘要
Abstract
[Objective]Although liquid hydrogen provides high energy density and clean combustion,it poses significant safety risks due to its low boiling point,high diffusivity,and flammability.Therefore,addressing the safety challenges associated with large-scale liquid hydrogen leaks is essential for operational safety and risk management in hydrogen infrastructure,particularly in large-scale storage areas.This study investigates the dispersion characteristics of hydrogen vapor clouds and subsequent fire hazards following catastrophic leakage events,providing critical insights into safety implications under diverse environmental conditions.[Methods]A numerical model based on the fire dynamics simulator(FDS)—an advanced computational fluid dynamics tool developed by the U.S.National Institute of Standards and Technology—was developed.The applicability and accuracy of FDS in hydrogen safety simulations were systematically validated through comparisons with experimental data,quantitative error analysis,and cross-validation using peer studies.The simulations examined leakage scenarios involving evaporation,vapor dispersion,and fire development,incorporating fluid dynamics,phase change,combustion,and thermal radiation processes.Environmental factors such as overhead obstructions and solar radiation were also considered.The leakage source was modeled as a liquid hydrogen storage tank located at the center of a large-scale storage area.The lateral dispersion behavior of the hydrogen cloud under varying wind speeds and its impact on structures located off the downwind direction were analyzed.Subsequently,three comparative scenarios were established:a baseline case,a case with overhead confinement,and one with solar radiation.The effects of ceiling obstructions and solar heating on hazardous exposure times and cloud dispersion were evaluated.Moreover,the fire development and potential hazards in the vicinity of the storage area following immediate ignition after leakage were examined.[Results]Simulation results indicated that:(1)Buildings located offset from the main wind direction were not affected by the lateral dispersion of the flammable hydrogen cloud.(2)The ceiling structure suppressed the vertical dispersion of the hydrogen cloud during the initial leakage phase and increased the horizontal transport rate,leading to a large gas-to-ground contact area and a prolonged hazardous exposure duration in near-field regions,which resulted in an increase in hazardous exposure time at Building2 by 5s.(3)Solar radiation played a minimal role in the early-stage evaporation and dispersion of liquid hydrogen.Its thermal effect grew with time,serving to prolong the hazardous exposure time at building facility 2 by 12 s through accelerated cloud dispersion,with a corresponding delay in far-field arrival due to enhanced dilution.(4)In the event of ignition,the liquid hydrogen fire developed extremely rapidly,reaching a flame height of 30 m and a lateral spread of 15 m within 9 s;the core flame temperature exceeded 700 ℃.In the simulated fire scenario,the thermal radiation intensity in the ceiling monitoring area consistently exceeded the safety threshold.The thermal radiation intensity exceeded 12.5 kW/m2,accounting for over 70％of the total simulation time,potentially causing structural damage such as steel failure and concrete spalling.[Conclusions]Quantitative studies on overhead confinement and solar radiation provide new insights into the potential risks of hydrogen facilities in complex environments,while research on the dynamic characteristics of accidental fires offers valuable information for the prevention of daily fires and the development of appropriate strategies to suppress fires.关键词
氢安全/液氢/泄漏扩散/火灾隐患/数值模拟Key words
hydrogen safety/liquid hydrogen/leakage and diffusion/fire hazards/numerical simulation分类
航空航天引用本文复制引用
王若彤,疏志勇,雷刚,梁文清,陈强,刘海洋,郑晓红,钱华..大型液氢库区泄漏扩散全尺度模拟及安全分析[J].清华大学学报（自然科学版）,2026,66(3):440-451,12.基金项目
江苏省科技厅科技成果转化项目(BA2023103) （BA2023103）
国家资助博士后研究人员计划(GZC20250416) （GZC20250416）
江苏省卓越博士后计划(025ZB473) （025ZB473）
